When installing the first plate, the parallelism with the structural axis must be checked. During installation, the straightness of the color steel plate at the cornice and ridge and the wave crest straightness of the color steel plate on both sides of the slope shall be strictly controlled. If the roofing color steel sheet has a joint for single slope, the lap point of color steel and rock wool foam cleaning board must be installed at the purlin, and the length of lap should be equal to or equal to 250mm. The overlapping length of the outer and inner cover plates of the ridge shall be ≥ 200mm; The outer cover plate shall be coated with transparent neutral sealing silicone adhesive on the inner layer of the overlapping area. It is strictly prohibited to apply glue on the surface of color steel plate.

屋面板安裝時，首先確定安裝起始點，該點的確定根據現場情況確定，一般選擇從一側山墻往另一側山墻安裝。屋面彩鋼巖棉泡沫凈化板的安裝：直接在彩鋼巖棉泡沫凈化板廠家的外表面用防水自攻螺釘固定，螺釘橫向固定在兩塊彩鋼板的搭接波峰上和板寬的中間波峰上。外墻面板的固定螺釘應使用拉線進行定位，保證橫平豎直、外觀整齊。緊固后隨手帶上與板材外表面顏色相匹配的裝飾帽。

During roof panel installation, the starting point of installation shall be determined first. The determination of this point shall be determined according to the site conditions. Generally, the gable shall be installed from one side to the other. The installation of roofing color steel wool foam purifying board is directly fixed on the outer surface of the manufacturer of the colored steel and rock wool foam purifying board with self tapping screws, and the screws are fixed horizontally on the overlapping peaks of the two color steel plates and the middle crest of the plate width. The fixing screws of the exterior wall panel shall be positioned with a stay wire to ensure horizontal and vertical and neat appearance. After fastening, wear a decorative cap matching the color of the outer surface of the plate.

安裝過程中嚴格控制彩鋼板在檐口和屋脊處的直線度，以及坡面兩側彩鋼板的波峰直線度。彩鋼巖棉泡沫凈化板安裝時，首先確定安裝起始點，一般選擇從一側山墻往另一側山墻安裝。安裝時還應用拉線拉出檐口控制基準線，并每隔15m左右設一控制網線。

During installation, the straightness of the color steel plate at the cornice and ridge and the wave crest straightness of the color steel plate on both sides of the slope shall be strictly controlled. When installing the color steel wool foam cleaning board, the installation starting point is first determined. Generally, it is installed from one side gable to the other side gable. During installation, the cornice control datum line shall be pulled out with a pull wire, and a control network cable shall be set every 15m.

當產品運到時，應檢查產品的質量、長度、數量、運輸損傷等，如果發現任何損傷請在接貨單上做出標記并請司機簽名，并有責任提供損壞說明。采用機械卸車時，應在堅實、平整的地面上卸車，貨叉與板材接觸時表面應覆有軟墊層或墊板，以免損傷板材。

When the product arrives, the quality, length, quantity and transportation damage of the product shall be checked. If any damage is found, please mark it on the receiving note and ask the driver to sign, and be responsible for providing damage instructions. When mechanical unloading is adopted, it shall be unloaded on a solid and flat ground. When the fork is in contact with the plate, the surface shall be covered with soft cushion layer or backing plate to avoid damaging the plate.

彩鋼巖棉泡沫凈化板人工卸車、搬運時應注意佩戴保護手套以避免板材表面磨損并保證安全。輕抬輕放，雙手將底部全部托起，不得單獨抬頂部面板，避免將板材撕裂；彩鋼巖棉泡沫凈化板廠家不得拖拉，以免磨傷、劃傷面板；避免板材彎曲，否則會造成板材內部填充材料斷裂及板材表面變形。

Attention should be paid to wearing protective gloves to remove the surface wear and ensure safety when unloading and transporting the colored steel rock wool foam purifying board. Lift and place gently, lift the bottom with both hands, and do not lift the top panel alone to avoid tearing the plate; Color steel and rock wool foam cleaning board manufacturers shall not delay, so as not to wear or scratch panels. Avoid bending of the plate, otherwise it will cause fracture of the filling material inside the plate and deformation of the plate surface.

以上就是今天小編給大家提供的精彩內容，更多的精彩內容請點擊進入我們的官方網站：濟南泡沫復合板http://www.dyhongsenfg.com

The above is the wonderful content of today's Xiaobian. Please click on our official website: Ji'nan foam composite board. http://www.dyhongsenfg.com